协力机械提供废纸打包解决方案!

液压打包机主压电机泵组采用永磁同步电动机泵

发布日期: 2019-11-10

  液压打包机主压电机泵组采用永磁同步电动机泵组后,根据电机与泵的技术性,高速允许1800r/min。因此,电机泵组即可以1800r/min的转速工作在主压/脱箱机构的低负载阶段(提高电机的负荷与能效)。

液压打包机

  前面已经叙述,在主压/脱箱机构待机时,使液压打包机电机泵组停转,必然节电,但通常情况,主压/脱箱机构待机均只有几十秒,为避免电机频繁地承受快速启动带来的瞬时大电流的冲击伤害,在几十秒内,也不适合让永磁同步电动机完全停止,经测算,在空载时,电机泵组以300r/min的转速为佳。主压电机采用永磁同步电动机后,在压缩一个棉包的过程,主压电机泵组的转速如上图。

  液压打包机电机的输出功率N=液压泵的功率=p·n·q·ηV/(612η),在主压上行和脱箱下行低负载阶段,p恒定,电机的输出功率与转速n成正比,在主压下行的初始阶段,负载虽不大,但也是逐步增大的。永磁同步电动机过额定频率(速)运转时为恒功率,当打包机电机泵组以1800r/min的转速工作时,必须设定液压压力发讯值p,当p·n·q·ηV(/612η)达到电机额定功率时,控制电机的转速n降低,保证电机不载。

  液压打包机永磁同步电动机低于额定频率运转时为恒转矩(扭矩),转矩=9550N/n。由于转矩恒定,空载时,当永磁同步电动机的转速为300r/min时,其输出功率仅为1500r/min转速时的1/5.

上一篇: 下一篇:
郑州协力建工设备有限公司©2019
地址: 河南省郑州市新密大隗工业园区    电话: 0371-67811068 86578886   手机: 13607648254 13213193797   传真:0371-67817108   网站地图 营业执照